Reasons to Use a Desiccant Commercial Dry Cabinet With Humidity Below 5 Percent

If you are looking for an inexpensive way to conserve energy, and can't afford the electric bill, consider building a specialized dry-walled unit in your home.wholesale desiccant dry cabinet with humidity below 5% The cheap moisture evaporator fans do not really save you any money - they tend to get hot and warm as well. For maximum effect, look for a dry-walled unit that contains a humidity control circuit, or condenser.

Dry cool air will save you money on energy bills - just keep in mind that the wall air is still moist.wholesale desiccant dry cabinet with humidity below 5% wholesale desiccant dry cabinet with humidity below 5% The best way to get dryness down to zero is to take the unit outside. You can do this by adding a few inches of seaweed or sand (roughly the size of a regular door mat).

This should help insulate the unit well enough to support special panels that will pull the dry air up through the floor, then let it out through the ceiling, which is good because it will cut down on the amount of electricity used. By looking for a product with an activated carbon filter in the finish, you can still get some seaweed, or granular calcium carbonate (the stuff you put on old corrugated cardboard for mailing), but it should be the least of your concerns.

Just make sure that you get a unit that will fit well in your house, and that will meet your needs, rather than being a Frankenstein of your personal preference. In addition, there is a problem with water getting in if the unit is located in a basement, since the system will need to be in a room where water does not normally enter. For this reason, many people prefer to use a unit that is wall mounted. Of course, this requires you to have room to mount it, and of course it also leaves you with the same problems with flooding, since the floor is much smaller than a basement floor.

Another thing to be aware of is the problem with the inside of the dry cabinet condensing off into steam as it is circulated. When doing so, a simple solution is to add some less expensive vapor-retaining compounds to the dryer. This might cost a bit more, but the extra money you spend is a small price to pay for energy savings.

A humidifier, or a dehumidifier, that is installed inside the dry cabinet, can certainly save you a lot of money. If you want the coolest, driest air possible, and you are willing to run out to the store every night to buy the moist air, then a humidifier is probably the way to go. If you live in a cold climate, however, you probably can't use a humidifier without blowing it into your walls, and you may lose much of the coolness of the air.

At least a third of the energy we use is lost through the roof of our homes, so even though the air outside may be warm, it does not have to be moist, too. It is far better to have the cooler air at the top of the house, than the hot dry air on the floor below. A system like the wet cabinet humidifier can work wonders for your wallet, too.

If you are looking for a way to conserve energy and save money, look for a moisture evaporator fan that is built right into the drywall, or in the drywall paneling. It won't necessarily save you money - it will still depend on your budget and the quality of the materials - but it will definitely help.

Tags:advanced desiccant dry cabinet baking | desccant dry cabinet with heating | wholesale desiccant dry cabinet baking